Textile mills of Pali district in Rajasthan and Tiruppur in Tamil Nadu have an annual turnover of over Rs 20,000 crore. But the rivers passing through these cities have paid a heavy price
PALI DISTRICT in Rajasthan has over 800 textile industries that employ about 50 per cent of the city’s population. The region has been a textile hub since the 1970s, with an annual turnover of over Rs 7,000 crore. But the industries have severely polluted river Bandi on whose banks the city is located.
The 40 km stretch of the river covered in a study by Delhi-based non-profit Centre for Science and Environment (CSE) in June this year bears testimony to the adverse impact the textile sector has had on the town. “The influx of untreated industrial effluents into Bandi has ruined most of the wells in the vicinity. Village residents have been forced to stop agricultural activities within two-three km of the river,” says Jaitpur-based activist Lakshman Dhulia.
The problem is not new. India’s first common effluent treatment plant (CETP) was set up in Pali in 1982 to treat industrial effluents. But not much has changed. “The textile units have expanded over the past 30 years. The water of river Bandi and Nehra dam located downstream stinks due to the discharge of untreated effluents,” complains Nathuram Charan, a local farmer.
“Of the 800 textile units in the town, 600 are under Central Pollution Control Board’s ‘red category’, denoting that they are highly polluting units,” says Anil Mehta, chairperson, Pali Water Pollution Control Research Foundation (PWPCRF), a local association of industrialists set up in 1994.
The CSE study found that almost all textile units falling under the red category send effluents to the four CETPS of the city without any primary treatment. “As per the pollution control board norms, every industry that falls under the red category and has been given consent to operate needs to have a primary treatment plant,” says Pukhraj Patel, president, Sri Kisan Paryavaran Sangharsh Samiti, a Pali-based non-profit working on water pollution and related problems since 2004.
In the study, 45 samples of surface and groundwater from different locations in Pali were tested. Almost 80 per cent of the surface water samples were found unfit for drinking. They were highly alkaline and had a high chemical oxygen demand (COD), indicating dangerous levels of organic pollutants. The levels of total dissolved solids (TDS) were four times higher than the standard (See ‘Contamination hubs’).
Concentration of chlorides, which impact reproductive rates of freshwater organisms and reduce their lifespan, were nine times higher. On the other hand, the level of dissolved oxygen, necessary for aquatic life, was nearly zero. CSE also tested 21 samples of effluents of mills located in the industrial zones and found that approximately 80 per cent of these samples were highly polluted, with COD levels 11 times higher than standard limits. Effluent samples collected from three CETP outlets were also found to contain low concentrations of phenolic compounds which can cause skin irritation and breathing problems.
Systemic problem
CSE had previously investigated Pali in December 2007 and pointed that the major problem in the area was inefficient treatment plants. There are several other problems that ail the process of disposing of industrial waste in Pali. There is no system for the transport of effluents from the textile units to CETPs. Tankers carry them and spillage during transport contaminates the soil. CETPs, which are based on dated technology, are not working at full capacity, treating only 17 million litres of effluents a day against their maximum capacity of 34.68 million litres a day. The sludge rejected after the process, which has all the pollutants trapped, is dried and disposed of in nearby areas.
“Many industries discharge effluents directly into the river, leading to severe pollution,” says Mhuveer Sukerlai, local activist and convener of Sri Kisan Paryavaran Sangharsh Samiti, a Pali-based non-profit working on water pollution related issues since 2004. The industries which do treat effluents follow sub-standard treatment parameters and are reluctant to upgrade their treatment technology.
Also, most textile industries in Pali are small scale units and were involved in hand printing of cotton textiles prior to the 1990s. But today 40 per cent of mills in Pali are synthetic textile mills and the dyes used in synthetic fabrics are more difficult to treat because they are acidic in nature. The treatment system has not been able to keep pace with the change of effluent character.
Moreover, infrastructure facilities of the state’s pollution control board are inadequate. “The regional laboratory is not in Pali. Samples go to Jodhpur and Jaipur for testing. To regulate the 700 dyeing units and other industries, there are only seven officials,” says R B Maurya, regional officer of Rajasthan Pollution Control Board.
The industry is even defiant of court orders. Hearing a public interest litigation filed in 2004, the Jodhpur High Court in 2007 ordered closure of 126 dyeing units located outside industrial areas. The court had ordered that a new industrial area be developed and units operating outside industrial areas be shut or shifted. But nothing changed and the industries continue to operate.
In 2012, Sri Kisan Paryavaran Sangharsh Samiti filed a case in the Jodhpur high court against textile unit operators, PWPCRF, Rajasthan Pollution Control Board, District Collector of Pali and the government of Rajasthan to suspend the functioning of all the textile units in Pali that were operating without “consent to operate” and to stop the discharge of untreated effluents into the Bandi river. On March 5 this year, the case was transferred to the National Green Tribunal which ordered closure of almost 600 textile units operating without the consent. The order is yet to be implemented because the industry has sought a review.
On right track
Tiruppur district in Tamil Nadu is another textile hub which was highly polluted but has managed to check pollution. With 6,250 textile-related industries, this district is one of the biggest knitwear centres in the world. The sector employs 0.6 million and has an annual revenue of over Rs 13,000 crore. In the 1990s, the town had no treatment plants. The dyeing units would simply release untreated effluents into the Noyyalriver which made it highly polluted. The Orathupalayam dam downstream also had contaminated water. “All along the banks of the river there were piles of sludge which would stink. Our lands were spoilt and cattle got sick,” recalls A P Kandaswamy, president of Noyyal Ayacut Association, a local farmers’ union.
But judicial intervention changed the scene. A two-decade-long legal battle, which started in 1996, ended with a large number of textile industries in Tiruppur adopting zero liquid discharge system (See ‘Neutralising effluents’).
— source downtoearth.org.in